Preventing and Repairing Broken Braces

Given the high level of pulling, tugging, and stretching that braces and suspenders endure, its no surprise that they break. And when they do, it can be an embarrassing moment, especially if your pants start slipping down. 

Where braces break 
On braces, the most common break occurs around the button holes on brace tabs (see diagram). This is where the braces experience the full extent of the pull on the button to hold the pants up.

There is an ongoing battle between the braces pulling on the button to hold up the pants, and the button pulling on the brace tabs to stay attached to the pants. Eventually, one or the other will succeed in breaking away, resulting in either a torn buttonhole and intact button on the pants, or a popped button and an intact buttonhole. 

Take for example, this picture from Norman Rockwell. You'll notice that the front, inner brace button has popped off, likely due to the sudden jerk to get away from the dog.

The battle of the button and the brace tab may be short-lived, if the button thread cuts into the brace tab, the thread will cause the tear. It's nearly impossible to repair a broken buttonhole on a brace tab, so it's recommended that buttons be sewn in just enough to hold the braces to the pants, but not so securely that the button doesn't pop-off when needed. This will help save many brace tabs and braces from being ruined.


The ability for braces to stretch is what makes them useful. But when braces are pulled or stretched beyond capacity, the buttons should pop-off to avoid the damages listed above. This saves the braces, and its an easy repair to re-sew a button on to a pair of pants to use the braces again, rather than buy a new pair of braces.


Here's some photos of people who could use a seamstress to sew on missing buttons. 

Both front, exterior brace buttons are popped off

The front left, exterior brace button has popped off

The front right, exterior brace button has popped off

Again, the front left, exterior brace button has popped off

Another example is presented below - this girl was a little over zealous when stretching her braces, or the button was not sewn on correctly. Regardless, the front, inner brace button is popped off (see below and close-up). This inner button is the common place for a button to be popped off in the front (although not always the case). This is because people pull your braces away from your body or you stretch the straps away from your body, putting the most strain on the front inner buttons, not the outer ones.

Notice the popped inner brace button

Close-up of popped front, inner brace button

When buying braces, inspect the brace tabs for firmness and quality - genuine leather is recommended (left), or woven material (right):

Secondly, a common place breaks occur is at the adjuster clip on the strap. The metal can wear down from frequent adjusting and use, causing it to lose its ability to hold the clip in place. A worn out clip will not hold the straps in place. 

A broken adjustor clip

A third place area suspenders and braces break is in their elasticity. Elastic straps wear down over time and become brittle. For instance, the braces shown below are starting to show signs of deteriorating condition.

Deteriorating elastic straps

A fourth place is around the brace tabs. These can become brittle, frayed, or simply wear out.

Frayed brace tab

Where suspenders break
Suspenders are attached pants and skirts with alligator clips that grip material. This is the frequent breakage point, when the clip fails to grip the material, either due to excessive use or poor quality. When you purchase suspenders, examine the clips for strength. If one of your favorite suspenders has a broken clip, head over to a sewing store and pick up a new clip.

Suspender straps may also be attached by buttons, rather than clips. In the photo below, the shorts have suspender straps attached to them, likely by buttons. Notice that the rear button of the lady on the right has popped off, leaving the strap hanging loose, whereas the lady on the left has both straps attached. This was likely due to the extra strain on the straps while riding the bicycles.

Another area suspenders break is a tear on the brace strap. This is less common, but does come from getting snags. The suspenders are likely past repairs. However, before you throw them out, why not use the clips on another pair of suspenders?

Torn suspender strap

What to do with broken braces and suspenders
If you have broken braces or suspenders, consider re-purposing them by getting the necessary supplies from a sewing store. If the brace tabs are broken, you can try a leather store to inquire if they can repair them. If not, donate it to a thrift store and someone else may value your reject!

Discussion time:

1. Where do your braces/suspenders break?
2. Do you have any stories of braces or suspenders breaking at unfortunate moments?

Note: all photos are used solely for non-commercial use and to illustrate braces in fashion. No plagiarism is intended.

Brace Tension

How tight do you wear your braces or suspenders? Are they lax and falling off your shoulders? Or are they firmly pulling up your pants and giving you a constant wedge? How do you find the right balance?

Braces and suspenders have different material – elastic, boxcloth, leather, and more (see Brace Materials). You can find the balance of tautness versus slack in the tension of braces over a short period of time simply by wearing them.

If the material is boxcloth, braided leather, or cloth, there is very minimal tension so the straps should remain at the same tension when you are standing as to when you are sitting. Set the length that you find most comfortable standing, sitting, and bending. You should be able to determine this within 10-20 minutes of wearing the braces.

If the material is elastic then there can be anywhere from minimal to super-stretch tension in the straps. If your pants are bobbing up and down every time you move, then the elastic could be worn out and you will need a new pair. If your braces are too tight and do not provide sufficient stretch when you bend down, you should loosen the straps. Firm suspender straps can cause stiffness in your shoulders, so be careful when wearing a new pair of elastic braces.

 

Generally, the wider the braces strap, the stiffer the tension, and the narrower the strap, the more stretch will be in the strap.

Avoid super-stretchy suspender straps, like these...

To find what works for you, try a few different brace materials (elastic, boxcloth, leather). Wear them for a day to determine their comfort and feel. You may discover that you prefer boxcloth over elastic straps.

Discussion time:

1. How do you find the tension in your braces/suspenders?
2. Do you find your pants ride up by wearing braces?

Note: all photos are used solely for non-commercial use and to illustrate braces in fashion. No plagiarism is intended.

Braces and Hats

You have probably noticed braces and suspenders popping up (pardon the pun!) everywhere recently. So what other accessories go with braces?

One of the most prominent accessories is a hat. Braces were a standard accessory during the 1920s and '30s. People also wore hats during this time. So it goes to say that hats and braces are a perfect pair!

Common styles included the bowler, fedora, and top hat. Here's a photo with a number of hats and rear side of a man's braces:

So here's some ideas to get you started:

 

 

What better way to relive the roaring ‘20s than with braces and a vintage hat? Its perfect for a man or women from casual to formal.

Discussion time:

• Do you wear a hat with braces?
• What other accessories do you wear with braces with?

Note: all photos are used solely for non-commercial use and to illustrate braces in fashion. No plagiarism is intended.

Braces with Shorts

Summer is a great time to show off your love of braces and suspenders. The hot weather means that you are wearing fewer layers of clothing, and so your braces will be on display all day. They are a conversation starter as well as an accessory to add that extra touch to an outfit.

When shorts are worn with braces they are suspended at the waist. This provides roominess around the waist which increases air circulation and reduces heat buildup – perfect for hot summer days!


But before you start snapping on a pair of suspenders to all your shorts, you should consider the nature of braces. One may argue that all shorts could be supported with suspenders. Taken to the extreme, you may say that males should wear suspenders with a bathing suit! That is simply comical and looks ridiculous. I am not arguing for a blanket approach to wearing braces.

So how should you wear braces with shorts? First, you should remember that suspenders are more formal in nature than a belt. Belts conjure up images of a working man; braces invoke a sense of sophistication. Braces and suspenders are simply more formal than belts. Therefore, to wear suspenders or braces with your shorts, you should do it when the occasion is more formal, such as at garden party or outdoor theater. 

Second, shorts are associated with athletic wear and physical exercise. It’s generally desired to have less articles of clothing when playing sports rather than more. Who wants to provide their opponent with the opportunity to snap their suspenders while running after a soccer ball, for instance.

Whenever you wear braces, they will speak for themselves. So be mindful of the design and style you wear. They should be simple, with solid colors or strips – no pastels or graphic designs. Here are some suggestions for achieving this look:

 Retailers are attaching straps to shorts this year, especially for females. Here's some examples:

If you want to get a Train Conductor look, you can add a pair of braces to stripped, blue shorts. Red braces will definitely catch someone's attention:

Discussion time:
1. Would you wear braces with shorts?
2. Do you find wearing suspenders in the summer to improve air flow or not?

Note: all photos are used solely for non-commercial use and to illustrate braces in fashion. No plagiarism is intended.